Author |
Message |
Jonas Knell
Yet to post message Username: holbrook
Post Number: 1 Registered: 06-2022
| Posted on Sunday, 29 January, 2023 - 16:40: | |
Hi Everyone... 2 weeks ago I filled up the R Type and noticed a small amount of fuel leaking from the car, positioned at approx. the center of the rear wheel. It wasn't very much and had thought that perhaps I had just overfilled the tank by accident. No fuel was notice or present after that. Today I filled the Tanks again, and again whilst filling I noticed fuel leaking again and again from the same position so thought perhaps there was an issue with the Fuel Filler hose (RH8118) either having a hole or such like. It was only short drive back from the petrol station I parked in the street I returned 40 mins later and found the fuel leaking onto the ground but this time it is closer to the rear of the suspension near the exhaust pipe. see videos. This is the first occasion any fuel has been leaking after the vehicle is stationary and not running and whilst parked in my garage for past week or so no fuel leaked only just now it has started as seen in the videos. I waiting for the fuel to leak to the point where perhaps the level falls below what ever is causing the leak. s I topped it up twice today, first time 15 litres then stopped because I saw the leak and was concerned about being on the petrol station, but then after not seeing any further leak went and topped it to the top which has now resulted in the fuel leaking as shown https://youtube.com/shorts/P0eqMYssl4c https://youtu.be/6UpjFpAf6UU As you can see its leaking quiet a bit so I wont be going anywhere in it. Hoping for advice... Does anyoine think it its the fuel filler hose or do they think its the tank. Also does anyone have any instructions on how to access and possibly remove the tank or how to work out where the leak is coming from - I don't have access to a lift or anything so if I have to get it lifted then will have to take it somewhere for assessment
(Message approved by david_gore) |
Bill Vatter
Experienced User Username: bill_vatter
Post Number: 151 Registered: 09-2004
| Posted on Tuesday, 31 January, 2023 - 08:12: | |
Most likely the main filler hose. The Service Instructions has a bit on replacing the hose. It's written for the Mk VI, but should be essentially the same procedure. On the Mk VI, you access the hose through the boot by taking off some interior panels. The Mk VI and R-type have differently shaped tanks and boots, and maybe you can get at yours from under the car. My experience is with the one on the Mk VI. Get some same diameter generic fuel filler hose from the parts store. |
Jonas Knell
Yet to post message Username: holbrook
Post Number: 1 Registered: 06-2022
| Posted on Tuesday, 31 January, 2023 - 08:33: | |
Hey Bill Yes I have located the hose for replacement and Im pretty certain it is that because it has stopped leaking now - I suspect I lost about 5 liters before it stopped so I assume the fuel is now below where the leak is.... I did check and there seems to be some screws inside the boot which may facilitate the replacement I'm still looking for proper instructions though. Oh I forgot to mention that my cap was stuck on as well so I am also assuming the leak hole or split in the hose may also have created some sort of vacuum as I had to use pliers to open the filler cap |
Bill Vatter
Experienced User Username: bill_vatter
Post Number: 152 Registered: 09-2004
| Posted on Wednesday, 01 February, 2023 - 21:17: | |
The cap will definately stick if you tighten it. There is no vacuum in there. That is not your problem. Run the cap on until it bottoms and leave it. DO NOT TIGHTEN. |